Volkswagen Tiguan Service and Repair Manual: Name Badges
Assembly Instructions for Name Badges and Emblems
Note
- It is not possible to remove the name badge without breaking it.
- Warm the name badges or emblems before removing using a Hot Air
Blower -VAG1416-.
- Only use Adhesive Remover -D 002 000 10-.
- Make sure the adhesive surfaces are free of dust and grease.
- Bond the name badges or emblems immediately after cleaning.
- Peel off the protective film just before installing.
- The temperature must be approximately 21 ºC (69.8 ºF).
Rear Name Badge Dimensions

- Name Badge
- Height Dimension
- From the bottom edge of the tail lamp to the name badge is 23 mm
- Side Dimension
- From the outer edge of the rear lid to the name badge is 25 mm
- Name Badge
- Name Badge
- Side Dimension
- From the outer edge of the rear lid to the name badge is 37 mm
- Height Dimension
- Between the name badges: 10 mm
Side Name Badge Dimensions
Volkswagen R GmbH "R-Line" optional equipment
Note
- It is not possible to remove the name badge without breaking it.
- The displayed dimensions are for the left side. The right side is
identical.
Left Fender Name Badge Dimensions

- Dimension -a- = 95 mm
- Transfer the -dimension a- from the end
of the name badge to the edge of the fender.
- Dimension -b- = 130 mm
- Transfer -dimension b- from the end of
the name badge up to the upper edge of the fender.
Special Tools

Special tools and workshop equipment required
- Torque Wrench 1783 - 2-10Nm -VAG1783-
- Hot Air Blower -VAG1416-
- Adhesive Strip Remover -VAS6349-

- Torque Wrench 1783 - 2-10Nm -VAG1783-
- Hot Air Blower -VAG1416-
- Adhesive Strip Remover -VAS6349-
- Trim Removal Wedge -3409-
- Double Cartridge Gun -VAS5237-
- Bonded Window Tool Kit -VAG1351-

- Torque Wrench 1331 5-50Nm -VAG1331-

Edition: K0059111121 - FU- 03/26/2015 - JY
Volkswagen R GmbH "R-Line" optional equipment
Note
More information about special attachments can be obtained from the
Volkswagen R GmbH Hotline.
Safety Precautions
Note
The special attachments wer ...
See More:
Volkswagen Tiguan Owners Manual > Airbag system: Front airbags
Fig. 69 Location and deployment zone
of the driver front airbag.
Fig. 70 Location and deployment zone
of the front passenger front airbag.
Read and follow the introductory information and
safety information first⇒Introduction
to the subject The vehicle is equipped with an Advanced Airb ...
Volkswagen Tiguan Owners Manual
Volkswagen Tiguan Service and Repair Manual
© 2018-2025 Copyright www.vwtiguan.org - 0.0675