VW Tiguan Manuals

Volkswagen Tiguan Service and Repair Manual: Outer Seal, Replacing and Installing

Volkswagen Tiguan Service and Repair Manual / Body exterior / Sunroof / Outer Seal, Replacing and Installing

  • Remove the front glass panel.
  • Remove the rear glass panel.

Volswagen Tiguan. Outer Seal, Replacing and Installing

  • Remove the outer seal -1- with the adhesive surface -3- from the roof -2-.

Volswagen Tiguan. Outer Seal, Replacing and Installing

  • Cut the profile of the outer seal -1- in the area -arrow- flush to the roof edge -4- all the way around.
  • The remainder -3- stays between the roof -4- and the assembly frame -2-.
  • Remove any adhesive residue using Adhesive Strip Remover - VAS6349-.
  • The adhesion surface on the roof cutout must be free of dust and grease.
  • Clean the adhesive surface thoroughly with Cleaning Solution -D 009 401 04-.
  • Wipe the adhesive surface on the roof cutout using the primer towel supplied.
  • Always pay attention to the drying time for the primer towel supplied.

Volswagen Tiguan. Outer Seal, Replacing and Installing

  • Center the new outer seal -1- so that the joint -arrow- is at the center of the rear roof opening.
  • Remove the protective film from the adhesive tape -4- on the new outer seal -1- and press the seal onto the roof -3- .
  • Press the seal on evenly so that it does not stretch and become too long.
  • Press the outer seal down using the Roller - 3356- two times evenly all around.
  • Install the rear glass sunroof panel.
  • Install the front glass sunroof panel.

Inner Seal, Replacing

Volswagen Tiguan. Inner Seal, Replacing

  • Remove the front glass panel.
  • Remove the rear glass panel.
  • Remove the inner seal -2- from the assembly frame -1-.
  • Remove any adhesive residue using Adhesive Strip Remover - VAS6349-.
  • Make sure there is no dust or grease on the adhesive surface.
  • Clean the adhesive surface thoroughly with Cleaning Solution -D 009 401 04-.
  • Wipe the adhesive surface on the assembly frame using the primer towel supplied.
  • Place the inner seal -2- in the center of the rear roof opening on the adhesive side of the assembly frame -1-.
  • Remove the protective foil from the adhesive tape on the inner seal in sections and press it on.
  • Press seal on evenly to prevent any excess length.
  • Press the inner seal down using the Roller - 3356- two times evenly all around.
  • Install the rear glass sunroof panel.
  • Install the front glass sunroof panel.
    Glass Sunroof Panel Seals, Replacing
    Remove the rear glass panel. Replace the Front Seal and the Inner Seal. Remove the seal from the rear glass sunroof panel -1- . Front seal Inner seal Remove any adhesive residue using ...

    Wind Deflector, Removing and Installing
    Removing Open the glass sunroof panel all the way forward. Unclip the clips -3- using a screwdriver from the mounting bracket -2- for the wind deflector -1- . Unclip the mounting bracket ...

    See More:

    Volkswagen Tiguan Owners Manual > Lights: Turn signal lever and high beam switch
    Fig. 81 Turn signal lever and high beam switch. Read and follow the introductory information and safety information first⇒Introduction to the subject Move the lever to the desired position. Right turn signal. Left turn signal. Switching high beams on ⇒  An indicator light ...

    Volkswagen Tiguan Owners Manual

    Volkswagen Tiguan Service and Repair Manual

    © 2018-2021 Copyright www.vwtiguan.org - 0.0167